Effects of abrupt introduction and removal of high and low digestibility corn distillers dried grains with solubles from the diet on growth performance and carcass characteristics of growing-finishing pigs

Two experiments were conducted to evaluate the effects of feeding continuously a diet containing 40% dried distillers grains with solubles (DDGS) or intermittently diets containing 20 or 40% DDGS on growth performance and carcass quality of pigs. Responses of the pigs to abrupt introduction and removal of dietary DDGS with differing concentrations of standardized ileal digestible (SID) AA were also evaluated. In Exp. 1, crossbred pigs (n = 216; initial BW = 51.3 ± 3.1 kg) were assigned randomly to 1 of 4 treatments, which included a corn-soybean meal control (CON), a 20% DDGS diet (D20), a switch between D20 and CON (D20-CON), and a switch between a 40% DDGS diet and CON (D40-CON) with 6 pens per treatment. Pigs abruptly introduced and removed from a 20% DDGS diet (D20-CON) exhibited no differences in growth performance or carcass quality compared with CON pigs. However, intermittently feeding a 40% DDGS diet (D40-CON) resulted in lighter HCW (P < 0.05) compared with all other treatments. In Exp. 2, crossbred pigs (n = 324; initial BW = 33.2 ± 3.0 kg) were assigned randomly to 1 of 6 treatments, including a corn-soybean meal control (CON), a 40% low SID AA DDGS diet (LD), a 40% high SID AA DDGS diet (HD), LD and CON diets alternated (LD-CON), HD and CON diets alternated (HD-CON), or HD and LD diets alternated (HD-LD) with 6 pens per treatment. Final BW and ADG were less (P < 0.05) for LD and HD-LD pigs compared with CON pigs, but HD pigs tended to have reduced (P < 0.10) final BW and ADG. Loin muscle area was smaller for LD and HD-LD pigs compared with CON pigs (P < 0.05). Percentage carcass lean was not affected by dietary treatment. Backfat of DDGS-fed pigs was more unsaturated than CON pigs, but AA digestibility of DDGS did not affect this response. Digestibility of AA in DDGS can influence pig performance and carcass quality when fed at high concentrations (40% or more). The use of a high SID AA DDGS source may diminish some of the negative responses observed for growth performance and carcass characteristics when feeding high concentrations of DDGS if accurate values of SID AA are used in diet formulation. Periodic inclusion and removal of 40% DDGS from diets did not adversely affect growth performance or carcass quality regardless of the SID AA digestibility of the DDGS used. These results indicate that it is possible to abruptly incorporate and remove DDGS from grower finisher swine diets without meaningful detrimental effects on growth performance or carcass quality.